International Journal of Nutrition

International Journal of Nutrition

International Journal of Nutrition

Current Issue Volume No: 2 Issue No: 4

Research Article Open Access Available online freely Peer Reviewed Citation

Microbiological and Nutritional Properties of Frankfurter-Type Fish Sausage

1Department of Animal Science, Faculty of Agriculture, Kwame Nkrumah University of Science and Technology, Kumasi, Ghana.


Fish meat is a common and broadly used food due to its high nutritional values yet the bones and flavour of fresh fish can be unpleasant. The unpleasant fishy flavour makes it difficult to handle and process. The fishy flavour is as a result of microbial presence and growth. Studies associated with microbial contaminations have concentrated more on the carcass. Such contaminations which affect the microbiological status of processed products can emanate from spices and other non-meat ingredients, environment, equipment and handlers. The successful application of processing/preservation technology results in the conservation of desirable qualities in stabilized and varietal fish products. This study sought to use fish in the manufacture of frankfurter-type sausages, which could have improved preservation characteristics without any adverse effects on sensory properties. The nutritional composition and microbiological safety of fresh fish and sausages were determined using the methods described by AOAC and ICMSF respectively. The study showed that, catfish sausages were higher in protein (15.69 %) and were lower in fat (10.66%) compared to the other sausages. Total Viable Counts (TVC) were within the accepted limits (106 and 107cfu/g) for fish and pork respectively. E. coli  was not detected in any of the treatments during frozen storage for 6 weeks. It was concluded that catfish frankfurter has high nutritive value because it contained less fat but with higher crude protein. Like pork frankfurters, both catfish and mackerel sausages could be stored for six weeks without any negative effects on microbial quality.

Author Contributions
Received 10 Jul 2018; Accepted 24 Jul 2018; Published 29 Aug 2018;

Academic Editor: Jie Yin, Institute of Subtropical Agriculture & University of Chinese Academy of Sciences, China.

Checked for plagiarism: Yes

Review by: Single-blind

Copyright ©  2018 Nkrumah T, et al.

Creative Commons License     This is an open-access article distributed under the terms of the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited.

Competing interests

The authors have declared that no competing interests exist.


Nkrumah T, Akwetey WY (2018) Microbiological and Nutritional Properties of Frankfurter-Type Fish Sausage . International Journal of Nutrition - 2(4):27-34.

Download as RIS, BibTeX, Text (Include abstract )

DOI 10.14302/issn.2379-7835.ijn-18-2212


The safety of meat for human consumption has become an essential part of the world’s health debate Güngör and Gökoğlu (2010)11. Food safety aspects of the meat industry were discussed by Hur et al. (2008)12 in sections which consider the growing awareness of food safety issues during the last two decades with respect to the importance of food inspection services, risk assessment and management to increasing life expectancy among populations in developed countries. Most meat processing plants have also begun to utilize the Hazard Analysis and Critical Control Point (HACCP) system in order to reduce pathogenic contaminations. Meat products are vulnerable to food borne pathogenic bacteria such as Listeria, Salmonella, and E.coli(Sachindra et al., 2005)22. Escherichia coli O157:H7 has been considered as an emerging pathogen since 1999 to be responsible for approximately seventy-three thousand (73,000) cases of infection, two thousand one hundred (2,100) hospitalizations and sixty-one (61) deaths in the U.S.A each year (USDA, 1999)28. Children and the elderly are more susceptible to developing complications such as hemolytic uremic syndrome (HUS) or thrombotic thrombocytopenic purpura (TTP), which may lead to kidney failure. Also, coliforms have been detected at various processing steps in the meat industry (Pavlov and Chukanski 2004)21. Therefore, efficient and effective preservation and or processing methods which prevent microbial contamination and extend product shelf life should be adopted in order to assure consumer safety.

African countries require food processing technologies that will meet the challenges of peculiar food security problems of the continent. Such technologies according to Anihouvi et al. (2012)2 should be affordable by the poor sectors of the community and should be able to address the problems of food spoilage and food borne diseases which are prevalent on the continent (Olapade and Karim, 2011)19.

For instance according to the FAO (2012)9, eight percent (8%) of harvested fish never get to the market and higher values (20 - 40%) of spoilage were recorded in hot humid environments.

Fish spoilage can be as a result of lipid oxidation and hydrolysis which leads to the development of rancidity during storage at sub-zero temperatures. According to FAO (2013)10 this is because large amounts of polyunsaturated fatty acid moieties are found in fish lipids; this is a major cause of deterioration of frozen fish. Moreover, storage facilities used by indigenous fish processors are problematic, because of high temperatures and humid climate (Oluwatoyin et al., 2010)20. Eating contaminated fish can cause illness (Sen, 2005)24, hence the importance of awareness creation on the need to access reliable knowledge on the quality and safety of all meat products meant for human consumption. According to Lobb et al. (2007)16 such critical measures of processing and preservation can help eradicate consumer’s attitudes and perceived risks and consequences of consuming contaminated foods.

The main objective of the study was therefore to produce two frankfurter-type sausages using catfish and Mackerel.

The specific objectives were to assess the microbiological safety and nutritional characteristics of the sausages produced with or without fish.

Materials and Methods

Experimental Location and Design

There were four treatments in all:- which were coded as T1, T2, T3 and T4. T1 represented pork frankfurter without corn starch; which also served as negative control, T2 was Mackerel frankfurter, T3 was Catfish frankfurter and T4 was pork frankfurter with corn starch which serve as the negative control.

The experimental design was Complete Randomized Design (CRD).

Sausage Preparation

Filleted frozen fish, lean pork and pork fat were minced separately using a mincer (MA®Superwolf, Germany) with a grinding sieve diameter of 5mm. Other non-meat/dry ingredients used in preparing the sausages were curing salt (table salt plus sodium nitrite )(NaNO2), phosphate in the form of disodium phosphate, (Na2HPO4)and mixed spice. Each treatment was chopped in a bowl cutter to obtain desirable consistence at 150C. Dry ingredients were added during chopping together with water/ice in order to dissolve and ensure proper mixing of all ingredients, as well as to control the temperature of the meat batter.

Each treatment was filled into 26mm diameter casings using a manually operated filling machine, and tied off into 6cm lengths. The sausages were hot smoked for 1 hour and scalded at 70°C for 30 min to achieve a core temperature of 65°C. A meat thermometer was used to monitor the core temperature of the sausages in order to prevent over cooking. The scalded sausages were allowed to cool under running tap water, packaged and labelled for storage in a freezer for quality analysis and for further studies.

Parameters Measured

Physico-Chemical Properties

Proximate analysis (moisture, ash, fat, crude protein and carbohydrates) was carried out at the Soil Chemistry Laboratory of the Department of Crop and Soil Science, KNUST using AOAC (1990)1 procedures. Ash was determined according to AOAC method 923.03.

Microbial Safety Total Viable Counts (TVCS) and Isolation of Escherichia Coli

Total microbial load and presence of E. coli were determined weekly as described by (ICMSF, 2002)15 for 6 weeks of frozen storage.

Statistical Analysis

Data obtained for proximate parameters were subjected to one way analysis of variance (ANOVA) using Genstat statistical package version-12 and significant differences between means were separated at 5% using Least Significant Difference test.

Results and Discussion

Okanović et al. (2013)18 indicated that fish sausage has higher protein (17.32%) and less fat (21.06%) content than sausages made from meat of other farm animals. FAO (2001)8 also reported lesser fat ranges in Mackerel (1.0% to 23.5%) and Catfish (2.1 to 3.8%) as well as protein (16% to 20%) and (17% to 19%) in Mackerel and Catfish respectively. However, protein and fat results from this study (Table 1) were higher, and the moisture content was lower than those reported by (IoM, 2002)14. IoM (2002)14, had earlier published that sausages made from Catfish contained 74.5% water, 3.16% fat and 13.73% protein. T1 (pork sausage without corn starch) and T4 (pork sausage with corn starch) had significantly (p<0.05) higher protein than T2 (Mckerel), suggesting that not all fish species have higher protein than livestock meats; thus quality of protein in processed meat depends on the content used. Although high protein contents were shown in Catfish (T3), the protein contents for the two fishes were within the normal range of values of protein in fish (15-25%) (Huss, 1995)13. The differences in protein contents of the fish sausages could be due to differences in species, feed availability, sexual maturity, spawning and season of catching (Oduor-Odote and Kazungu, 2008)17. The presence of high levels of ash in T2 and T3 indicates that the total inorganic mineral contents in fish frankfurter are high probably due to the ability of fish to absorb certain trace elements from surrounding water (Tacon, 1992)25. The results obtained for ash contents are however within the ranges recorded by Burgaard and Jorgensen (2011)3.

Table 1. Proximate composition(%) of sausage used (As - Is)
Source Moisture Protein Fat Carbohydrate Ash
Frankfurter- type        
T1 60.02b 14.26b 19.27b 1.89c 4.37b
T2 55.98c 13.29c 23.30a 2.24bc 5.56a
T3 64.87a 15.69a 10.66c 3.21a 5.92a
T4 60.95b 14.64b 18.69b 2.51b 3.57c <.0001 0.0005 <.0001 0.0022 <.0001

Superscript abcdacross rows are significantly different (p<0.05)
T1 = pork frankfurter without corn starch
T2 = mackerel frankfurter
T3 = catfish frankfurter
T4 = pork frankfurter with corn starch

Other studies (Tozer, 2001)27 have reported ash values in the range of 1.05 - 1.29 %, which are lower than ranges found in this study (3.7- 5.92 %). The proximate composition of fish is species specific (Shearer, 1994), so it is logic to see differences between the examined fish sausages. However all values were within the normal ranges of proximate composition (water 66-84%, protein 15-25 % and fat 0.1 -24 %) (Huss, 1995)13.

The amount of carbohydrate in fish muscle is generally small to be of any significance in any balanced diet (FAO, 1985)7. Fish is usually less than 1% but 2-5% can be obtained in fatty species and striated muscle where carbohydrate occurs as glycogen and as part of the chemical constituents of nucleotides (FAO, 2013)10. Carbohydrate was added to T2, T3 and T4 in the form of corn flour. Treatment T3 recorded significantly higher (p<0.05) carbohydrate (3.51 %) followed by T4 (2.51%), T2 (2.24%) and T1 (1.89%). Meat muscle normally contains only traces of carbohydrates, in the form of sugars, sugar phosphates and glycogen (Wilson, 2002)29.

The chemical content can be a source of free ribose after post mortem autolytic changes (FAO, 2013)10. Therefore the high carbohydrate reported in this experiment could be due partially to the 1.2% corn flour added to treatments T2, T3 and T4. However T1 which had no corn flour added during product formulation recorded 1.18% carbohydrate.

Microbial Counts and Isolation of E. coli.

Table 2, Table 2.1 and Table 2.2, show Total Viable Count (TVC) in raw minced meats, raw sausage batters and cooked frankfurters, respectively. The TVCs in all the analysis were within accepted limits (pork= 107 and fish= 106cfu/g) as recommended by ICMSF (2002)15. Though the TVCs observed were within accepted limits, raw minced pork recorded higher counts numerically (2.5 × 105cfu/g) than Mackerel (1.9 × 105cfu/g) and Catfish (1.8 × 105cfu/g). The low TVC in minced catfish and Mackerel could be as a result of high ash contents (Table 4.2). Tacon (1992)25 reported that high mineral contents can sometimes retard the growth of certain microorganisms.

Table 2. Total Viable Counts (TVCs) for raw minced meat
Type of minced meat TVC cfu /g Recommended TVC ( cfu /g) (ICMSF, 2002) 15
Pork 2.5 ×105 107
Mackerel 1.9 ×105 106
Catfish 1.8 ×105 106

Table 2. 1. Total Viable Counts (TVCs) for raw sausage batter
Type of frankfurter TVC cfu /g Recommended TVC ( cfu /g) (2002)
T1 2.5 ×105 107
T2 9.9 ×104 106
T3 4.4 ×104 106
T4 1.1 ×105 107

T1 = Pork frankfurter without corn starch
T2 = Mackerel frankfurter
T3 = Catfish frankfurter and
T4 = pork frankfurter with corn starch
Table 2. 2. Total Viable Count (TVCs) of sausages during frozen storage
Storage (week) Type of frankfurter Recommended TVC ( cfu /g) (ICMSF 2002) 15
TVCs ( cfu /g)
  T1 T2 T3 T4 T1 T2 T3 T4
1 1.7 ×105 1.9 ×105 7.1 ×104 1.2 ×105 106 105 105 106
2 7.6 ×104 2.3 ×104 9.0 ×104  6.0 ×103 106 105 105 106
3 5.0 ×103 2.0 ×103 2.2 ×104 7.3 ×103 106 105 105 106
4 2.7 ×104 3.7 ×104 8.0 ×103 7.0 ×102 106 105 105 106
5 8.4 ×104 1.3 ×105 4.4 ×104 9.3 ×104 106 105 105 106
6 9.0 ×104 1.3 ×105 3.0 ×105 2.6 ×104 106 105 105 106

TVCs obtained after chopping minced meats into batter (Table 2.1) were also within accepted limits by ICMSF (2002)15.

The observed TVCs values ranged from 4.4 × 104cfu/g (T3) to 2.5 ×105cfu/g (T1). There was a one log reduction in TVCs of minced Mackerel and Catfish after batter production.

Also the addition of non- meat ingredients (spice mix, water, phosphate, corn starch) may have reduced microbial population in raw fish batter. Sachindra et al. (2005)22 reported that micro- organisms could gain access into sausage from meat, spices, and other ingredients, from environment, equipment, and handlers during processing. Thus the observed one log reduction in TVCs of the fish based batter is not in conformity to the assertion by Sachindra et al. (2005)22. However processing minced pork to obtain raw pork batter (T1 and T4) (Table 3.0) did not change the microbial counts (T1 and T4).

Table 2.2 is the TVC for frankfurters during frozen storage. The observed counts were all within acceptable limits; since 106cfu/g is the maximum permissible level for aerobic plate counts in meat products ICMFS (2002). Thus, all the frankfurters analysed over the six weeks of frozen storage can be classified as acceptable for human consumption. E. coli were not detected in this study at all stages of sampling (Table 2.4, Table 2.3). (Table 2.5) In fact, no growth was observed during week five and six of frozen storage. This could be attributed to the fact that, the production process of cooked meats in this study was not compromised in any way. De Roever (1998)6 indicated that, the presence of E. coli in food is an indicator of cross-contamination.

Table 2. 3. Isolation of organism (E. coli) in raw minced meat
Minced meat E. coli
Pork Not detected
Mackerel Not detected
Catfish Not detected

Table 2. 4. Isolation of organism (E. coli) in raw sausage batter
Type of sausage batter E. coli
T1 Not detected
T2 Not detected
T3 Not detected
T4 Not detected

Table 3. Isolation of Organism (E. coli) in Frankfurter-type Sausage during frozen storage (1-6weeks)
Sausage Type
Storage week T1 T2 T3 T4
Week 1 ND ND ND ND
Week 2 ND ND ND ND
Week 3 ND ND ND ND
Week 4 ND ND ND ND
Week 5 ND ND NG NG
Week 6 NG NG NG NG

*ND - Not Detected
*NG - No Growth

Tacon, (1992)25 reported of presence of E. coli in pork sausages. Several authors found that E. coli O157:H7 was associated with derived retail meat products (Chinen et al., 2001; Chapman et al., 2001)5,4. Of the 1750 ground pork and fish samples analyzed, 20 (1.1%) were positive for E. coli O157 (Samadpour et al., 2006)23.

The use of curing salt (containing nitrite) in the formulation of the frankfurter could also have contributed to eliminating pathogenic organisms in the products during storage because nitrite is effective as antimicrobial addictive in meat systems.

The spices used in this experiment had no E. coli presence. It has been suggested that several factors (environmental factors) may contribute to the presence of pathogens, including poor handling, poor hygiene practices, cross-contamination from food handlers and storage conditions (Chinen et al., 2001)5. This indicates that sufficient hygienic measures for microbial control were put in place during the manufacturing process of the study.

Conclusions and Recommendations

Catfish frankfurter was higher in protein compared to mackerel and pork sausages. Lower fat contents were also recorded in Catfish sausages.

Microbes were present in both fish and pork sausages but lesser Total Viable Counts (TVC) were recorded as frozen storage weeks increased. In fact TVCs recorded were all within the accepted limits as recommended by International Commission on Microbiological Specification on Food. E. coli was not detected in all raw ingredients as well as their respective frankfurter samples. This indicates that sausages were produced under good hygienic conditions and proper handling practices were adhered to at all stages of processing.

It can therefore be concluded that catfish frankfurter has high crude protein, less fat, and is safe for consumption after processing into sausage and frozen stored for six weeks.

It is recommended that, further work could be done to determine amino acids and mineral compositions in catfish and mackerel sausages.


  1. 1. (1990) Association Of Analytical Chemist (AOAC). Official Methods of Analysis of AOAC International (15thedition) , Washington, D.C 145-152.
  1. 2.Anihouvi V B, Kindossi J M, Hounhouigan J D. (2012) Processing and Quality Characteristics of Some Major Fermented Fish Products from Africa: A Critical Review Department of Nutrition and Food Science - University of Abomey- Calavi, 01BP 526. , Cotonou, BENIN 292.
  1. 3.Burgaard M G, Jørgensen B M. (2011) Effect of Frozen Storage Temperature on Quality-Related Changes in Rainbow Trout (Oncorhynchusmykiss). , Journal of Aquatic Food Product Technology 20(1), 53-63.
  1. 4.Chapman P A, Malo A C, Ellin M, Ashton R, Harkin M A. (2001) . Escherichia coli O157 in Cattle and Sheep at Slaughter, on Beef and Lamb Carcasses and in Raw Beef and Lamb Products in South Yorkshire, UK.International Journal of Food Microbiology 64(1), 139-150.
  1. 5.Chinen I, Tanaro J D, Miliwebsky E, Lound L H, Chillemi G et al. (2001) Isolation and Characterization of Escherichia coli O157: H7 from Retail Meats in Argentina. , Journal of Food Protection 64(9), 1346-1351.
  1. 6.C De Roever. (1998) Microbiological Safety Evaluations and Recommendations on Fresh Produce. Food Control. 9(6), 321-347.
  1. 7. (1985) Food and Agriculture Organization (FAO). Energy and Protein Requirements. Report of a Joint FAO/WHO/UNU Expert Consultation. World Health Organization. Technical Report Series 724, 1-206.
  1. 8. (2001) Food and Agriculture Organization (FAO). Sharing Innovative Experience; Example of Success. in Agriculture and Rural Development in the South 5, 240-254.
  1. 9. (2012) Food and Agriculture Organization (FAO). Further Processing of fish; Fisheries and Aquaculture Assessed3/04/2014.
  1. 10. (2013) Food and Agriculture Organization (FAO). Nutritional element of fish; United Nations FAO/UN for a world without hunger; Fisheries and Aquaculture Department. Pp 25. Assessed 2/12/2013.
  1. 11.Güngör E, Gökoğlu N. (2010) Determination of Microbial Contamination Sources at a Frankfurter Sausage Processing Line. , Turkish Journal of Veterinary and Animal Sciences 34(1), 53-59.
  1. 12.Hur S J, Park G B, Joo S T. (2008) A comparison of the meat qualities from the Hanwoo (Korean native cattle) and Holstein steer. , Food and Bioprocess Technology 1(2), 196-200.
  1. 13.Huss H H. (1995) Quality and Quality Changes in Fresh Fish. FAO Fisheries Technical paper, Paper No. 348
  1. 14. (2002) Institute of Medicine (IoM). Dietary Reference Intakes for Energy, Carbohydrate, Fiber, Fat, Fatty acids. Cholesterol, Protein, and Amino acids.National Academic Press,Washington, D.C. Pp 1357.
  1. 15. (2002) International Commission on Microbiological Specifications for Foods (ICMSF). Microorganisms in foods: (Vol 7). Microbiological testing in food safety management.New York:Kluwer Academic/Plenum Publishers. 363.
  1. 16.Lobb A E, Mazzocchi M, Traill W B. (2007) Modeling Risk Perception and Trust. in Food Safety Information within the Theory of Planned Behavior, Food Quality and Preference 18(2), 384-395.
  1. 17.Oduor-Odote P M, Kazungu J M. (2008) The Body Composition of Low Value Fish and their Preparation into a Higher Value Snack Food. , Western Indian Ocean Journal of Marine of Science 7(1), 111-117.
  1. 18.Okanović Đ, Ljubojević D, Ćirković M, Đorđević V, Karan D et al. (2013) . , Characteristics of Sausages Produced of Carp Meat (Savremenapoljoprivreda).Contemporary Agriculture.62(1-2): 83-90.
  1. 19.Olapade O J, Karim M A. (2011) Utilization of Bonga (Ethmalosafimbriatabodwich) Fish Concentrate in Bread Baking in Njala-Mokonde Community, Sierra Leone. , Journal of Research in Forestry, Wildlife and Environment 3(2), 119-125.
  1. 20.Oluwatoyin D K, Williams S B, Awujola A F. (2010) Indigenous Fish Processing and Preservation Practices among Women in Southern Nigeria. , Indian Journal of Traditional Knowledge 9, 668-672.
  1. 21.Pavlov A, Chukanski P. (2004) Critical Control Points in Assessment of Microbiological Risk in a Small Meat Processing Enterprise. , Bulgarian Journal of Veternary Medicine 7, 167-172.
  1. 22.Sachindra N M, Sakhare P Z, Yashoda K P, Rao D N. (2005) . Microbial Profile of Buffalo Sausage During Processing and Storage. Food Control 16(1), 31-35.
  1. 23.Samadpour M, Barbour M W, Nguyen T, Cao T M, Buck F et al. (2006) Incidence of enterohemorrhagic Escherichia coli, Escherichia coli O157, Salmonella, and Listeria monocytogenes in retail fresh ground beef, sprouts, and mushrooms. , Journal of Food Protection 69, 441-443.
  1. 24.Sen D P. (2005) . Chemical Composition and their Technological Significance.Advances in Fish Processing Technology 1, 43-119.
  1. 25.Tacon A G. (1992) Nutritional Fish Pathology: Morphological signs of nutrient deficiency and toxicity. in farmed fish (No. 330). Food and Agriculture Organization 116-210.
  1. 26.TapiadeDaza M S, Alzamora S M, Chanes J W, Gould G. (1996) . Combination of Preservation Factors Applied to Minimal Processing of Foods. Critical Reviews in Food Science and Nutrition 36(6), 629-659.
  1. 27.Tozer K N. (2001) Quality Improvement and Shelf-life Extension of Fish Filets from three Aquaculture Species. The Faculty of Graduate Studies of The University of Guelph, Master of Science Thesis. 314.
  1. 28. (1999) United State Department of Agriculture, (USDA). Aquaculture Research Service: Database for standard reference. 41.
  1. 29.Wilson R P. (2002) Amino acids and proteins. , In Fish Nutrition (Eds:Halver, J.E.and Hardy,R.W.Academicpress 143-179.

Cited by (1)

  1. 1.Mputu Kanyinda Jean-Noël, Pascal Nsambu Mukondwa, Dieudonné Musibono, 2020, Mercury Pollution Linked To Gold Panning In DR Congo: Contamination Of Aquatic Systems And Health Impact On Residents, European Journal of Medical and Health Sciences, 2(3), 10.24018/ejmed.2020.2.3.350